I have 94 civic Ex which I have just rebuilt the engine (700miles on it so far) and now when I drive it around it just dies randomly. It has compression, spark, and no fuel pressure when it dies and I crank it over. Then I let it sit for awhile and it will start again run for about 15 mins and die. With the same symptoms comp, spark, no fuel. There is no CEL. I think this is a symptom of an electrical short in the fuel system. The injector seals were replaced just 2 days ago and then the problem started to happen. I have two ideas about what it could be, a) the mechanic is a monkey and messed something up, or b) the kill switch hooked into the fuel pump power line is shorting out. What do you guys think?

 

check the kill switch for sure bet thats the issue might want to check the fuel filter and fuel pressure regulator

 

I pulled the interior panel off like 5 minutes ago and the wires going into the crimped connector had broken and were failing inconsistantly. soldered a new one on this time on both wires and it fired right up afterwards. Now I'll just drive it and see if the problem goes away.



I'm seriously macgyver